2016 Ford Fusion Fuse Box Diagram

Power Distribution Box

WARNING:  Always disconnect the battery before servicing high-current fuses. WARNING:  To reduce risk of electrical shock, always replace the cover to the power distribution box before reconnecting the battery or refilling fluid reservoirs.

The power distribution box is located in the engine compartment. It has high-current fuses that protect your vehicle’s main electrical systems from overloads.If the battery has been disconnected and reconnected, some features will need to be reset.  

Fuse or relay number	Fuse amp rating	Protected components
1	30A3	Wide open panoramic roof 1.
2	–	Starter relay.
3	15A1	Rain sensor.
4	—	Blower motor relay.
5	20A3	Power point 3 – Back of console.
6	—	Not used.
7	20A1	Powertrain control module – vehicle power 1.
8	20A1	Powertrain control module – vehicle power 2.
9	—	Powertrain control module relay.
10	20A3	Power point 1 – driver front.
11	15A2	Powertrain control module – vehicle power 4.
12	15A2	Powertrain control module – vehicle power 3.
13	10A2	Powertrain control module – vehicle power 5.
14	10A2	Powertrain control module – vehicle power 6.
15	—	Run-start relay.
16	20A3	Power point 2 – console.
17	—	Not used.
18	—	Not used.
19	10A1	Run-start electronic power assist steering.
20	10A1	Run/start lighting.
21	15A1	Run/start transmission control.   Transmission oil pump start/stop.
22	10A1	Air conditioner clutch solenoid.
23	15A1	Run-start.   Blind spot information system.   Rear view camera.   Adaptive cruise control.   Heads-up display.   Voltage stability module.
24	—	Not used.
25	10A2	Run-start anti-lock brake system.
26	10A2	Run-start powertrain control module.
27	—	Not used.
28	—	Not used.
29	5A1	Mass air flow monitor.
30	—	Not used.
31	—	Not used.
32	—	Electronic fan 1 relay.
33	—	A/C clutch relay.
34	—	Not used.
35	—	Not used.
36	—	Not used.
37	—	Not used.
38	—	Electronic fan 2 relay.
39	—	Electronic fan coil 2 and 3 relay.
40	—	Horn relay.
41	—	Not used.
42	—	Fuel pump coil relay.
43	—	Not used.
44	—	Not used.
45	—	Not used.
46	—	Not used.
47	—	Not used.
48	—	Not used.
49	10A1	Keep alive power.
50	20A1	Horn.
51	—	Not used.
52	—	Not used.
53	10A1	Power seats.
54	10A2	Brake on off switch.
55	10A2	ALT sensor.

¹Micro fuse.²Dual micro fuse.³M-type fuse.

Power Distribution Box – Bottom

There are fuses located on the bottom of the fuse box. To access the bottom of the fuse box, do the following:

1. Release the two latches, located on both sides of the fuse box.
2. Raise the inboard side of the fuse box from the cradle.
3. Move the fuse box toward the center of the engine compartment.
4. Pivot the outboard side of the fuse box to access the bottom side.

Fuse or relay number	Fuse amp rating	Protected components
56	—	Not used.
57	20A1	Diesel vaporizer or E100.
58	30A1	Fuel pump feed.
59	30A2	Electronic fan 3.
60	30A2	Electronic fan 1.
61	—	Not used.
62	50A2	Body control module 1.
63	25A1	Electronic fan 2.
64	—	Not used.
65	20A1	Front heated seat.
66	—	Not used.
67	50A2	Body control module 2.
68	40A1	Heated rear window.
69	30A1	Anti-lock brake system valves.
70	30A1	Passenger seat.
71	—	Not used.
72	20A1	Trans oil pump.
73	20A1	Rear heated seats.
74	30A1	Driver seat module.
75	25A1	Wiper motor 1.
76	30A1	Power lift-gate module.
77	30A1	Climate control seat module.
78	40A1	Trailer tow module.
79	40A2	Blower motor.
80	25A1	Wiper motor 2.
81	40A1	Inverter.
82	–	Not used.
83	20A1	TRCM shifter.
84	30A1	Starter solenoid.
85	30A1	Wide open panoramic roof 2.
86	–	Not used.
87	60A2	Anti-lock brake system pump.

¹ M-type fuse.²J-type fuse.

Passenger Compartment Fuse Panel

The fuse panel is located under the instrument panel to the left of the steering column.Note:   It may be easier to access the fuse panel if you remove the finish trim piece.

Fuse or relay number	Fuse amp rating	Protected components
1	10A1	Lighting (ambient, glove box, vanity, dome, trunk).
2	7.5A1	Memory seats, lumbar, power mirror.
3	20A1	Driver door unlock.
4	5A1	Not used (spare).
5	20A1	Subwoofer amplifier.
6	10A2	Heated seat relay coil.
7	10A2	Not used (spare).
8	10A2	Not used (spare).
9	10A2	Not used (spare).
10	5A2	Keypad.   Power decklid module.   Cellphone passport module.
11	5A2	Not used (spare).
12	7.5A2	Climate control.   Gear shift
13	7.5A2	Steering wheel column lock.   Cluster.   Datelink logic.
14	10A2	Battery electronic control module.
15	10A2	Datalink gateway module.
16	15A1	Child lock.   Decklid-liftglass release.
17	5A2	Tracking and blocking.
18	5A2	Ignition.   Push button stop start switch.
19	7.5A2	Passenger airbag disabled indicator.   Transmission range.
20	7.5A2	Adaptive headlamp.
21	5A2	Humidity and in–car temperature sensor.
22	5A2	Occupant classification sensor.
23	10A1	Delayed accessory (power inverter logic, moonroof logic).
24	20A1	Central lock unlock.
25	30A1	Driver door (window, mirror).
26	30A1	Front passenger door (window, mirror).
27	30A1	Moonroof.
28	20A1	Amplifier.
29	30A1	Rear driver side door (window).
30	30A1	Rear passenger side door (window).
31	15A1	Not used (spare).
32	10A1	Global positioning system.   Display.   Voice control.   Adaptive cruise control.   Radio frequency receiver.
33	20A1	Radio.   Active noise control.   CD changer.
34	30A1	Run-start bus (fuse 19, 20, 21, 22, 35, 36, 37, circuit breaker).
35	5A1	Restraints control module.
36	15A1	Auto-dimming rear view mirror.   Continuous control damping suspension.   Rear heated seats.
37	15A1	All wheel drive.   Heated steering wheel.
38	30A	Not used (spare).

¹Micro fuse.²Dual micro fuse.

2016 Ford Fusion Owners Manual

Changing a Fuse

Fuses

WARNING:  Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.

If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components.Fuse Types

Callout	Fuse Type
A	Micro 2
B	Micro 3
C	Maxi
D	Mini
E	M Case
F	J Case
G	J Case Low Profile