Vehicle fuse box diagrams, images, and videos.
2022 Kawasaki KLX140R L Spark Arrester Spark Arrester This vehicle is equipped with a spark arrester. It must be properly maintained to ensure its efficiency. In accordance with the Periodic Maintenance Chart, clean the spark arrester. NOTICE The spark arrester must be installed correctly and functioning properly to provide adequate fire protection. Spark Arrester … Read more
2022 Kawasaki KLX140R L Drive Chain Drive Chain For safety and to prevent excessive wear, the drive chain must be checked, adjusted, and lubricated before riding. If the chain becomes badly worn or maladjusted- either too loose or too tight- it could jump off the sprockets or break. WARNING A chain that breaks or … Read more
2022 Kawasaki KLX140R L Handlebar Handlebar To suit various riding positions, the handlebar can be adjusted by turning the handlebar holders around. Remove the number plate (see Choke Knob Adjustment). Remove the handlebar clamp bolts, the clamps and the handlebar. Check the handlebar for bent or crack. A. Handlebar Clamps B. Handlebar Clamp Bolts … Read more
2022 Kawasaki CONCOURS 14ABS Idle Speed Idle Speed Idle Speed Adjustment Start the engine, and warm it up thoroughly. Adjust the idle speed by turning the idle adjusting screw. NOTE While the engine is cold, the fast idle system automatically raises the engine idling speed. 1 050 1 150 r/min (rpm) A. Idle Adjusting Screw … Read more
2022 Kawasaki CONCOURS Throttle Control System Throttle Control System Throttle Grip Throttle Grip Free Play Inspection Check that the throttle grip moves smoothly from fully open to close, and the throttle closes quickly and completely by the return spring in all steering positions. If the throttle grip does not return properly, have the throttle control … Read more
2022 Kawasaki CONCOURS 14ABS Air Cleaner Air Cleaner This motorcycle’s air cleaner element consists of a wet paper filter that cannot be cleaned. Air Cleaner Element Removal Remove the bolts with washers. Remove the front fuel tank cover. A. Bolts with Washers B. Front Fuel Tank Cover Turn the key knob to “ON” position. Set … Read more
2022 Kawasaki CONCOURS 14ABS Coolant Coolant Coolant Level Inspection Position the motorcycle so that it is perpendicular to the ground. Check the coolant level through the coolant level gauge on the reserve tank located to the left of the engine. The coolant level should be between the F (Full) and L (Low) level lines. A. … Read more
2022 Kawasaki CONCOURS 14ABS Final Gear Case Oil Final Gear Case Oil Oil Level Inspection Use the center stand by holding the motorcycle vertical on level ground. Remove the filler cap. NOTICE Be careful not to allow any dirt or foreign materials to enter the gear case. Check the oil level. If it is low, … Read more
2022 Kawasaki CONCOURS 14ABS Engine Oil Engine Oil Oil Level Inspection If the engine is cold, start the engine and run it for several minutes at idle speed. Stop the engine, then wait several minutes until the oil settles. NOTICE Racing the engine before the oil reaches every part can cause engine seizure. Check the … Read more
2022 Kawasaki CONCOURS 14ABS Periodic Maintenance Periodic Maintenance A: Service at number of years shown or indicated odometer reading intervals, whichever comes first. B: For higher odometer readings, repeat at the frequency interval established here. C: Service more frequently when operating in severe conditions: dusty, wet, muddy, high speed, or frequent starting/stopping. D: California model … Read more