2023 Volvo V60 Recharge Plug-in Hybrid Specifications for fluids and lubricants
Topping up washer fluid
Note
- When approx. 1 litre (1 qt) of washer fluid remains in the reservoir, the message Refill washer fluid, level low appears together with the
symbol in the driver display. - When the Refill washer fluid, level low message together with the symbol appears on the driver display, it is time to refill the washer fluid
- Open the bonnet with the handle in the passenger compartment and then with the handle under the front edge of the bonnet.
- Open the washer fluid reservoir cap.
- Washer fluid is filled into the reservoir with the blue cap. The reservoir is used for windscreen washers, rear window washers and headlamp washers. (Option/accessory.)
- Top up with washer fluid.
- Close the washer fluid reservoir cap and then close the bonnet.
Prescribed grade: Washer fluid recommended by Volvo – with frost protection during cold weather and for temperatures below freezing point.
Important
Use Volvo genuine washer fluid or equivalent with a recommended pH of between 6 and 8, in working dilution (e.g. 1:1 with neutral water).
Important
Use washer fluid with antifreeze when the temperature is below freezing to avoid the fluid freezing inside the pump, reservoir and hoses.
Volume:
- Cars with headlamp washing: 5.5 litres (5.8 qt).
- Cars without headlamp washing: 3.5 litres (3.7 qt).
Air conditioning – specifications
A/C decal
Decal for R134a
Decal for R1234yf
Symbol explanation R1234yf
| Symbol | Meaning |
|---|---|
 |
Caution |
 |
Mobile air conditioning system (MAC) |
 |
Lubricant type |
 |
A trained and certified technician is required in order to service the mobile air conditioning system (MAC) |
 |
Flammable refrigerants |
Refrigerant
The refrigerant amount is printed on the decal located on the underside of the bonnet.
Cars with R134a refrigerant
Warning
Cars with R1234yf refrigerant
Warning
The air conditioning system contains pressurised refrigerant R1234yf. In accordance with SAE J2845 (Technician Training for Safe Service and Containment of Refrigerants Used in Mobile A/C System), service and repair of the refrigerant system must only be performed by trained and certified technicians in order to ensure the safety of the system.
Compressor oil
| Volume | Prescribed grade |
|---|---|
| 100 ml (3.38 fl. oz.) | PAG SP-A2 |
Evaporator
(Only applies to cars with R1234yf refrigerant)
The A/C system’s evaporator must never be repaired or replaced with a previously used evaporator. A new evaporator must be certified and labelled in accordance with SAE J2842.
Brake fluid – specifications
Prescribed grade: Volvo Original or equivalent fluid compliant with a combination of Dot 4, 5.1 and ISO 4925 class 6.
Note
It is recommended that brake fluid is changed or filled by an authorised Volvo workshop.
Transmission fluid – specifications
Automatic gearbox
| Prescribed transmission fluid: | AW-1 |
Note
Check with your Volvo dealer if you are not sure which variant your car is equipped with.
Fuel tank – volume
| All engines | |
|---|---|
| Litres (approx) | 60 |
| US gallons (approx) | 15,9 |
Adverse driving conditions for engine oil
Check the oil level more frequently for long journeys:
- towing a caravan or trailer
- in mountainous regions
- at high speeds
- in temperatures colder than -30 °C (-22 °F) or hotter than +40 °C (+104 °F).
The above also applies to shorter driving distances at low temperatures. Choose a fully synthetic engine oil for adverse driving conditions. It provides extra protection for the engine. Volvo recommends:
Important
In order to fulfil the requirements for the engine’s service intervals, all engines are filled with specially adapted synthetic engine oil at the factory. The choice of oil has been made very carefully with regard to service life, starting characteristics, fuel consumption and environmental impact. Approved engine oil must be used in order that the recommended service intervals can be applied. Only use a prescribed grade of oil for both filling and oil change, otherwise, there is a risk of the service life, starting characteristics, fuel consumption and environmental impact of the car affected. If engine oil of the prescribed grade and viscosity is not used, engine-related components may become damaged. Volvo disclaims any liability for any such damage. Volvo recommends that oil changes are carried out at an authorised Volvo workshop.
Engine oil – specifications
Engine oil grade and volume for each respective engine alternative can be read in the table. Volvo recommends:
| Engine | Engine code
The engine code, component number and serial number can be found on the engine. |
Volume, incl. oil filter
(litres, approx.)
|
Oil grade |
|---|---|---|---|
| T6 AWD | B4204T52 | 5,6 | Castrol Edge Professional V 0W-20 or VCC RBS0-2AE 0W-20 |
| T8 AWD | B4204T53 | 5,6 | |
| T8 AWD | B4204T56 | 5,6 | |
| T8 AWD | B4204T57 | 5,6 |