Ranger Owner’s Manual

FUSE BOX LOCATIONS

APre-fuse box. BEngine compartment fuse box. CPassenger compartment fuse box. DHigh current fuse box, if available. EEngine vacuum pump relay box. FEngine cooling fan relay box.

 Note:   The passenger compartment fuse box is on the right-hand side for right-hand drive vehicles. 

Pre-fuse Box:

Your vehicle has a pre-fuse box in the engine compartment attached to the positive battery post. This box contains several high current fuses. If you need to replace these high current fuses, see an authorized dealer. 

Engine Compartment Fuse Box – Vehicles with Hydraulic Power Assist Steering

WARNING:  To reduce risk of electrical shock, always replace the cover to the power distribution box before reconnecting the battery or refilling fluid reservoirs.

Open the fuse box cover to access the fuses.

Engine Compartment Fuse Box- Vehicles with Electronic Power Assist Steering

WARNING:  Always disconnect the battery before servicing high current fuses. WARNING:  To reduce risk of electrical shock, always replace the cover to the power distribution box before reconnecting the battery or refilling fluid reservoirs.

The engine compartment fuse box has high-current fuses that protect your vehicle’s main electrical systems from overloads.When you disconnect and reconnect the battery, you need to reset some features.   See Changing the 12V Battery. Lift the release lever at the rear of the cover to remove it. 

Passenger Compartment Fuse Box

The fuse box is behind the access cover on the outermost side of the steering column.

High Current Fuse Box

Your vehicle has a pre-fuse box in the engine compartment below the engine compartment fuse box. This box contains several high current fuses. If you need to replace these high current fuses, see an authorized dealer.

Engine Compartment Relay Box (2.3L)

AElectric vacuum pump relay box. BEngine cooling fan relay box.

The relay boxes are in the engine compartment near the cooling fan. 

FUSE SPECIFICATION CHART

Power Distribution Box – Vehicles with Hydraulic Power Assist Steering

WARNING:  Always disconnect the battery before servicing high current fuses. WARNING:  To reduce risk of electrical shock, always replace the cover to the power distribution box before reconnecting the battery or refilling fluid reservoirs.

The engine compartment fuse box has high-current fuses that protect your vehicle’s main electrical systems from overloads. When you disconnect and reconnect the battery, you need to reset some features.  See Changing the 12V Battery.  Lift the release levers at the rear of the cover to remove it.

Fuse Location	Fuse Rating	Protected Component
F1	60A1	Passenger compartment fuse box supply (Battery).
F2	60A1	Passenger compartment fuse box supply (Battery).
F3	50A1	Engine cooling fan (2.5L).
60A1	Glow plug control module (2.2L).
F4	40A1	Anti-lock brake system module.
F5	30A1	Power windows (front and rear).
F6	–	Not used.
F7	–	Not used.
F8	–	Not used.
F9	20A1	Cigar lighter.
F10	20A1	Auxiliary power socket instrument panel.
F11	30A1	Blower motor.
F12	25A1	Four-wheel drive (4WD) motor power.
F13	20A1	Starter solenoid.
F14	20A1	Heated rear window.
F15	15A2	Vaporizer glow plug (2.2L).
F16	10A2	Air conditioning clutch.
F17	25A1	Power windows (front).
F18	25A2	Windshield wiper motor.
F19	–	Not used.
F20	–	Not used.
F21	15A2	Horn.
F22	10A2	Fuel injectors.
F23	10A2	Differential lock solenoid.
F24	–	Not used.
F25	15A2	Ignition coils (2.5L).   Temperature mass air flow sensor (TMAF) (2.2L).   Glow plug module (2.2L).   Vacuum control valve (VCV) (2.2L).   Electronic vacuum regulator valve (EVRV) (2.2L).
F26	7.5A2	Electronic control module (ECM).
F27	–	Not used.
F28	10A2	Exhaust gas sensors (2.5L).   Relay coils.
F29	15A2	Electronic control module (ECM).
F30	–	Not used.
F31	20A2	Auxiliary power socket (rear console).
F32	5A2	Air conditioning pressure switch (2.2L, 2.5L).
F33	–	Not used.
F34	–	Not used.
F35	20A2	Passenger compartment fuse box supply (Ignition).
F36	5A2	Anti-lock brake system module.
F37	10A2	Headlamp leveling.
F38	20A2	Heated seat.
F39	10A2	Power mirrors.
F40	10A2	Vaporizer pump (2.2L).
F41	–	Not used.
F42	10A2	Alarm horn.
F43	–	Not used.
F44	–	Not used.
F45	25A2	Anti-lock brake system module.
F46	20A2	Battery isolator.
F47	40A1	Trailer tow module.
F48	–	Not used.
F49	–	Not used.
F50	5A2	Ignition relay.   Relay coils.
F51	20A1	Trailer tow.

¹J-case fuse.²Mini fuse.

Relay Number	Protected Component
R1	Not used.
R2	Wiper on or off.
R3	Horn.
R4	Air conditioning clutch.
R5	Differential lock.
R6	Wiper Hi or Lo.
R7	Engine cooling fan low (2.5L).
R8	Engine cooling fan high (2.5L).
R9	Flex-fuel pump (2.5L).   Vaporizer glow plug (2.2L).
R10	Heated rear window.
R11	Not used.
R12	Not used.
R13	Electronic control module (ECM) power hold.
R14	Ignition.
R15	Four-wheel drive (4WD) motor 2 (clockwise).
R16	Four-wheel drive (4WD) motor 1 (counterclockwise).
R17	Four-wheel drive (4WD) motor.
R18	Anti-theft alarm horn.
R19	Starter.
R20	Not used.
R21	Not used.
R22	Not used.
R23	Not used.
R24	Not used.
R25	Not used.
R26	Blower motor.
R27	Not used.

Passenger Compartment Fuse Box – Vehicles with Hydraulic Power Assist Steering

Fuse Location	Fuse Rating	Protected Component
F56	20A3	Fuel pump.
F57	–	Not used.
F58	–	Not used.
F59	5A3	Passive anti-theft system (PATS).
F60	10A3	Interior lamp.   Driver door switch pack.   Mood lights.   Puddle lights.   Automatic shifter.   Footwell lamp.
F61	–	Not used.
F62	5A3	Rain sensor module.
F63	–	Not used.
F64	–	Not used.
F65	–	Not used.
F66	20A3	Driver door unlock, central double locking ground.
F67	5A3	Stop lamp switch.
F68	–	Not used.
F69	5A3	Instrument cluster.   Integrated control module (ICM).
F70	20A3	Central locking.
F71	5A3	Air conditioning.
F72	7.5A3	Alarm horn.
F73	5A3	On-board diagnostics II.
F74	20A3	Main beam.
F75	15A3	Front fog lamps.
F76	10A3	Reversing lamp.   Rear view mirror.
F77	20A3	Washer pump.
F78	5A3	Ignition switch.
F79	15A3	Not used (spare).
F80	20A3	Audio.
F81	5A3	Interior motion sensor.
F82	20A3	Washer pump ground.
F83	20A3	Central locking ground.
F84	20A3	Driver door unlock.   Central double locking ground.
F85	7.5A3	Instrument cluster.   Parking assist control module.   Manual air conditioning.
F86	10A3	Restraint system.   Passenger airbag deactivation indicator.
F87	–	Not used.
F88	–	Not used.
F89	–	Not used.

³Mini fuse.

Power Distribution Box – Vehicles with Electronic Power Assist Steering

Fuse Location	Fuse Rating	Protected Component
1	15A4	Not used (spare).
2	–	Starter motor solenoid relay.
3	5A4	Rain sensor.   USB power point (2.0L, 2.2L, 3.2L).
4	–	Blower motor relay.
5	20A4	Auxiliary power point.
6	–	Water-in-fuel filter heater relay (2.0L).
–	Transmission relay (2.3L).
–	Not used (2.2L, 3.2L).
7	20A5	Powertrain control module.
8	20A5	Exhaust gas recirculation (EGR) cooler bypass control – vacuum solenoid valve (2.0L).   Volumetric control valve (2.2L, 3.2L).   Exhaust gas recirculation (EGR) cooler bypass (2.2L, 3.2L).   Temperature mass air flow (2.2L, 3.2L).   Universal exhaust gas oxygen sensor (2.2L, 3.2L).   Cannister vent solenoid (2.3L).   Fuel vapor shut off valve (2.3L).   Cannister purge valve (2.3L).   Variable cam timing valve 1 and 2 (2.3L).   Heated oxygen sensors (2.3L).
9	–	Powertrain control module relay.
10	20A4	Auxiliary power point.
11	15A6	Glow plug module (2.0L).   Not used (spare) (3.2L less exhaust emissions control).   NOx sensor. Particulate matter sensor (2.0L, 3.2L with exhaust emission control system).   Ignition coils (2.3L).
12	15A6	Turbo bypass valve actuator (2.0L).   Wastegate actuator (2.0L).   A/C compressor and control valve. (2.0L).   Coolant pump (2.0L).   Fan drive.   Glow plug module (2.2L, 3.2L).   AC control valve (2.3L).   Transaxle warmer (2.3L).   Auxiliary water pump (2.3L).   Turbo bypass (2.3L).
13	15A6	Not used (spare).
14	15A6	Crankcase ventilation heater (2.0L).   Not used (spare) (2.2L, 2.3L, 3.2L).
15	–	Run/Start relay.
16	20A4	Auxiliary power point.
17	20A4	Auxiliary power point.
18	10A5	Fuel pump relay coil (2.2L, 3.2L).   Not used (spare) (2.0L, 2.3L).
19	10A5	Electronic power assist steering.
20	10A5	Headlamp switch.   Headlamp leveling.
21	15A5	Transmission control module.
22	10A5	Air conditioning compressor.
23	7.5A5	Rear view camera.   Adaptive speed control radar.   Head up display module.   Image processing module A (IPMA) (vehicles without Start-Stop).   Voltage quality module (vehicles with Start-Stop).
24	10A5	Not used (spare) (2.0L).   Air conditioning pressure switch diesel with manual transmission (2.2L, 3.2L).   Electric vacuum pump relay coil (2.3L).
25	10A6	Anti-lock brake system.
26	10A6	Tachograph.
27	–	Not used.
28	10A5	Powertrain control module.
29	–	Not used.
30	–	Not used.
31	–	Not used.
32	–	Fuel pump relay.
33	–	Air conditioning clutch relay.
34	15A5	Center high mount stop lamp.
35	15A5	Transmission control module.
36	–	Not used.
37	10A5	Heated exterior mirror (2.0L, 2.2L, 3.2L).   Not used (spare) (2.3L).
38	–	USB charge point relay (2.3L).   Not used (2.0L, 2.2L, 3.2L).
39	–	Four-wheel drive (4WD) power relay.
40	–	Center high mount stop lamp relay.
41	–	Horn relay.
42	–	Four-wheel drive (4WD) motor number 2 relay.
43	15A5	Reductant dosage control module (2.0L, 3.2L).   Not used (2.2L, 2.3L).
44	5A5	Not used (spare).
45	5A5	Water-in-fuel filter heater relay coil feed (2.0L).   Not used (spare) (2.2L, 2.3L, 3.2L).
46	10A6	Not used (spare).
47	10A6	Brake pedal switch.
48	20A5	Horn.
49	20A5	Steering column lock.
50	15A5	Reductant dosage control module (2.0L, 3.2L).   Not used (2.2L, 2.3L).
51	–	Not used.
52	–	Not used.
53	15A5	Rear differential lock.
54	10A6	Reductant dosage control module (2.0L, 3.2L).   Not used (2.2L, 2.3L).
55	10A6	Reductant dosage control module (3.2L).   Not used (2.0L, 2.2L, 2.3L).
86	–	Four-wheel drive (4WD) motor number 1 relay.

⁴M-type fuse.⁵Micro 2 fuse.⁶Micro 3 fuse.Note:   Spare fuse amperage may vary.

Power Distribution Box – Bottom

There are fuses on the bottom of the fuse box. To access the bottom of the fuse box:

Toward the front side of the vehicle.

1. Release the two latches on both sides of the fuse box.
2. Raise the rear side of the fuse box from the cradle.

3. Move the fuse box toward the rear side of the engine compartment and rotate as shown.
4. Pivot the rear side of the fuse box to access the bottom side.
5. Release the two latches to open the fuse cover.

Fuse Location	Fuse Rating	Protected Component
56	20A7	Not used (spare).
57	–	Not used.
58	–	Not used.
59	25A8	Four-wheel drive (4WD).
60	30A8	Fuel pump.
61	30A7	Left-hand heated windshield element (2.0L, 2.2L, 3.2L).   Not used (spare) (2.3L).
62	50A8	Body control module.
63	15A7	USB charge port (2.3L).   Not used (spare) (2.0L, 2.2L, 3.2L).
64	20A7	Trailer tow connector.
65	20A7	Heated seats (with SYNC) (2.0L, 3.2L).
66	30A7	Right-hand heated windshield element (2.0L, 2.2L, 3.2L).   Not used (spare) (2.3L).
67	50A8	Body control module.
68	20A7	Rear window defroster.
69	30A7	Anti-lock brake system valves.
70	20A7	Passenger power seat.
71	40A8	Water-in-fuel filter heater (2.0L).
20A8	Transmission (2.3L).
–	Not used (2.2L, 3.2L).
72	–	Not used.
73	30A7	Trailer tow module.
74	20A7	Driver power seat.
75	–	Not used.
76	–	Not used.
77	–	Not used.
78	–	Not used.
79	40A8	Blower motor.
80	–	Not used.
81	40A7	Inverter.
82	60A8	Anti-lock brake system.
83	30A7	Windshield wipers.
84	30A7	Starter motor solenoid.
85	30A7	Power roller shutter.
87	40A8	Trailer tow module.

⁷M-type fuse.⁸LPJ-type fuse.

Battery Mounted Fuse Link

Fuse Location	Fuse Rating	Protected Component
1	225A	Alternator (2.2L, 3.2L).
300A	Alternator (2.0L, 2.3L).
2	125A	Electronic power assist steering.

Battery Monitor Sensor Fuse

Fuse Location	Fuse Rating	Protected Component
1	3A9	Battery monitor sensor.

⁹ATO fuse.Engine Compartment Relay Box (2.3L) 

AElectric vacuum pump relay box. BEngine cooling fan relay box.

Press both latches to remove the cover.

High Current Fuse Box

Fuse Location	Fuse Rating	Protected Component
1	80A	Engine cooling fan (2.3L).
70A	Glow plugs – diesel (2.0L, 2.2L, 3.2L).
2	125A	Body control module.
3	50A	Body control module (vehicles without start-stop).   Voltage quality module – Rear parking aid camera.   Adaptive cruise control.   Head up display module.   Image processing module A (IPMA) (vehicles with start-stop).
4	–	Busbar through to power distribution box.
5	100A	Electric booster heater (2.0L, 2.2L, 3.2L).
40A	Electric vacuum pump (2.3L).

Passenger Compartment Fuse Box – Vehicles with Electronic Power Assist Steering

The fuse box is below and outermost of the steering column behind the access cover.

Fuse Location	Fuse Rating	Protected Component
1	–	Not used.
2	7.5A10	Not used (spare).
3	20A10	Driver door lock.   Fuel filler door.
4	5A10	Not used (spare).
5	20A10	Not used (spare).
6	10A11	Not used (spare).
7	10A11	Not used (spare).
8	10A11	Anti-theft alarm horn.
9	10A11	Telematics modem.
10	5A11	Not used (spare).
11	5A11	Interior motion sensor.
12	7.5A11	Electronic control panel.   Climate control.
13	7.5A11	Instrument cluster.   Steering column control module.   Data link connector.
14	10A11	Not used (spare).
15	10A11	Data link module.   Data link connector.   II.
16	15A10	Door rear double lock.
17	5A11	Battery back-up sounder.
18	5A11	Ignition system.   Push button ignition switch.
19	7.5A11	Not used (spare).
20	7.5A11	Reductant dosage control module (2.0L, 2.2L, 3.2L).   Not used (spare) (2.3L).
21	5A11	In-vehicle temperature and humidity sensor.   Electric booster heater (2.0L, 2.2L).
22	5A11	Not used (spare).
23	10A10	Inverter.   Door lock switch.
24	20A10	Central locking system.
25	30A10	Driver side power windows.
26	30A10	Not used (spare).
27	30A10	Not used (spare).
28	20A10	Not used (spare).
29	30A10	Not used (spare).
30	30A10	Not used (spare).
31	15A10	SYNC.   Tachograph (without SYNC) (2.0L, 2.2L, 3.2L).
32	10A10	Radio transceiver module.   Global positioning system module.   Door entry remote.   Tachograph (vehicles with SYNC) (2.0L, 2.2L, 3.2L).
33	20A10	Audio unit.
34	30A10	Run/Start relay.
35	5A10	Restraints control module.
36	15A10	Auto-dimming interior mirror.   Mirror adjustment control.
37	20A10	Heated seats (without SYNC) (2.0L, 2.2L).   Not used (spare) (2.3L, 3.2L).
38	30A12	Power windows.

¹⁰Micro 2 fuse.¹¹Micro 3 fuse.¹²PTC fuse.Note:   Spare fuse amperage may vary.

CHANGING A FUSE

Fuses

WARNING:  Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.

If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components.

Fuse Types

Callout	Fuse Type
A	Micro 2
B	Micro 3
C	Maxi
D	Mini
E	M Case
F	J Case
G	J Case Low Profile

To download the complete user manual, please download the following file:

https://www.fordservicecontent.com/Ford_Content/vdirsnet/OwnerManual/Home/Index?Variantid=8281&languageCode=EN&countryCode=USA&VIN=&userMarket=GBR&div=f