Ecosport Owner’s Manual

by
Contents hide
1 FUSE BOX LOCATIONS – LHD
2 FUSE BOX LOCATIONS – RHD
3 FUSE SPECIFICATION CHART
4 CHANGING A FUSE

FUSE BOX LOCATIONS – LHD

Battey Fuse Box

This fuse box in attached to the battery positive terminal.

Engine Compartment Fuse Box:

This fuse box is located in the engine compartment.

Passenger Compartment Fuse Box

This fuse box is located behind the glove box. To access the fuse box, do the following:

  1. Open the glove box and release the clips.
  2. Remove the storage compartment.

Note:   Any improper modification to the electrical system can compromise the safety of the vehicle, implying risk of fire or engine damage. For any clarifications or questions, contact a Ford Distributor.

FUSE BOX LOCATIONS – RHD

Battey Fuse Box

This fuse box in attached to the battery positive terminal.

Engine Compartment Fuse Box

This fuse box is located behind the glove box. To access the fuse box, do the following:

  1. Unattach and remove the plastic cover.

Note:   Any improper modification to the electrical system can compromise the safety of the vehicle, implying risk of fire or engine damage. For any clarifications or questions, contact a Ford Distributor.

FUSE SPECIFICATION CHART



WARNING   WARNING:  Always disconnect the battery before servicing high current fuses.
WARNING   WARNING:  To reduce risk of electrical shock, always replace the cover to the power distribution box before reconnecting the battery or refilling fluid reservoirs.

Your vehicle may not be equipped with all of the features listed in the fusing tables. This information describes all fusing for all available vehicle models.

Engine Compartment Fuse Box

Fuse  Fuse amp rating  Protected components  
1  60A  Engine cooling Fan 2 relay.  
2  50A  Engine cooling Fan 1 relay.  
3  60A  Glow Plug relay (Diesel).  
4  40A  ABS with electronic stability program valves.  
5  20A  Steering column lock relay.  
6  40A  Front blower motor relay.  
7  10A  Brake on/off Switch.  
8  20A  Moonroof module.  
9  15A  Rear washer relay.   Front wiper motor relay coil.  
10  7.5A  A/C clutch relay.  
11  5A  Power point relay coil.   Horn relay coil.   Fuel pump relay coil (except Diesel).  
14  10A  Heated mirrors.  
15  5A  Rain sensor.   Rear washer relay coil.  
16  10A  Rear window wiper motor.  
17  20A  Front power point / Cigar lighter.  
18  20A  Rear power point.  
19  –  Not used.  
20  20A   30A  Powertrain control module.   Powertrain control module (Diesel DV5FD).  
21  15A  Oxygen sensor heater.   Catalyst monitor sensor (1.0L).   Canister purge valve (1.0L).   Variable camshaft timing solenoid valves (1.0L).   Volume control valve – fuel metering unit (Diesel DV5FD).   EGR Cooler Bypass control (Diesel DV5FD).   Vacuum Solenoid valve (Diesel DV5FD).   Temperature / Mass air flow sensor (Diesel DvNeo).  
22  10A  Glow plug relay coil (Diesel DvNeo only).   Glow Plug module (Diesel DvNeo only).   Engine cooling Fan 1 relay coil.   Engine cooling Fan 2 relay coil.   A/C Clutch relay coil.   Variable A/C compressor valve.   Variable oil pump control (1.0L).   Electronic vacuum regulator valve (1.0L).   Puller fan relay coil (1.0L).   Run/On water pump (1.0L).   Auto transmission warmer unit.   Active Griller Shutter.   All Wheel Drive Module.  
22  5A  Engine Cooling Fan 1 relay coil (Diesel DV5FD).   Engine cooling Fan 2 relay coil (Diesel DV5FD).   A/C Clutch relay coil (Diesel DV5FD).   Glow plug relay coil (Diesel DV5FD).   Active Grill Shutter (Diesel DV5FD).   Fuel Pump relay coil (Diesel DV5FD).  
23  20A  Ignition coils (1.0L).   Buffer Amp Module (Diesel DvNeo only).  
24  10A  Variable Oil Pump control (Diesel DvNeo only).   Electric Heated Thermostat (Diesel DvNeo only).  
25  15A  Amplifier module power 1.  
26  20A  Trailer tow module – battery Charge.1  
27  –  Not used.  
28  10A  Left horn.  
29  10A  Right horn.  
30  15A  Heated steering wheel.  
31  –  Not used.  
32  30A  Body control module battery power.  
33  60A  ABS with electronic stability program pump.  
34  50A  Trailer Tow Module.1  
35  40A  Heated backlite relay.   Radio diversity antenna.  
36  30A  Starter relay.  
37  40A  Supplemental air heater 1 relay.  
38  20A  Left low beam lamp relay.  
39  20A  Right low beam lamp relay.  
40  25A  Heated seats.  
41  15A  Amplifier module power 2.  
42  7.5A  Puller fan relay (1.0L).  
46  30A  Rear left door control module.   Driver power window switch power (Left hands drive, Driver One Touch Up/Down only).  
47  20A   25A  Fuel pump relay (1.0L).   Electronic Fuel Pump relay (Diesel DV5FD).   Electronic Fuel Pump relay (Diesel DvNeo only).  
48  30A  Passenger door control module (right hands drive).   Driver Door Control Module (Left hands drive).  
49  20A  Transmission Oil Pump power (1.0L).   Fuel Heater relay (Diesel).  
55  10A  Headlamp leveling.  
56  5A  Electronic power steering module.   Powertrain control module.  
57  10A  Transmission Oil Pump logic (1.0L).   Fuel Heater relay coil (Diesel).  
58  10A  Rear view camera.   Blind spot modules.  
59  5A  ABS module.  
60  5A  Heated backlite relay coil.   Heated windshield right/left relay coil.  
63  25A  Front wiper motor.  
64  30A  Body control module – run/start bus.  
69  40A  Heated windshield left.  
70  40A  Heated windshield right.  
74  –  Not used.  
75  –  Not used.  

1Trailer wiring provision for authorized Dealer trailer tow module installation.

Relay  Circuits switched  
12  Powertrain control module.  
13  Starter relay.  
43  Power point relay.  
44  Front wiper motor relay.  
45  Front blower relay.  
50  Run/Start relay.  
51  Steering column lock relay.  
52  Horn relay.  
53  Left low beam lamp relay.  
54  Rear washer relay.  
61  Heated Backlite relay.   Heated mirrors.   Radio diversity antenna.  
62  Engine cooling fan 2 relay.  
65  Fuel pump relay (1.0L) .   Fuel Heater relay (Diesel).  
66  Right low beam lamp relay.  
67  A/C clutch relay.  
68  Engine cooling Fan 1 relay.  
71  Glow Plug relay (Diesel).  
72  Heated windshield right relay.  
73  Heated windshield left relay.  
76  Supplemental air heater 2 relay.  
77  Puller Fan relay (1.0L).   Electronic Fuel Pump relay (Diesel DV5FD).  
78  Not used.  
79  Supplemental air heater 1 relay.  

Passenger Compartment Fuse Box

Fuse  Fuse amp rating  Protected components  
F01  5A  Restraints control module.  
F02  5A  Humidity and incar temperature sensor.  
F03  10A  Reverse parking aid module.  
F04  10A  Ignition switch.   Push start switch.   Key in switch.  
F05  20A  Central lock relay (BCM internal relay).   Central unlock relay (BCM internal relay).  
F06  10A  Driver and passenger power window switch illumination (Driver one touch up/down only).   Driver power window switch delayed accessory (Driver one touch up/down only).   Moonroof switch illumination.   Moonroof module Delayed Accessory.  
F07  30A  Driver Door Control Module (Right hands drive).   Passenger Door Control Module (Left hands driver).  
F08  5A  Not used.  
F09  5A  Electrochromic inside mirror.   Gear shift.   Passenger airbag deactivation indicator.  
F10  10A  Smart data link connector – power.  
F11  5A  Vehicle With Embedded Modem Module (only).  
F12  5A  Intrusion sensor module (RHD).   Inclination Sensor module (RHD).  
F13  15A  Driver Unlock relay (BCM internal relay).   Double Lock relay (BCM internal relay).  
F14  30A  Driver Power Window switch power (Right hands driver, driver one touch up/down).   Rear right door control module.  
F15  15A  Trailer tow.  
F16  15A  Forward-looking camera.  
F17  15A  SYNC.   Electronic finish panel.  
F18  7.5A  Not used.  
F19  7.5A  Battery backup sounder module (RHD).  
F20  10A  Not used.  
F21  7.5A  Climate control module.  
F22  7.5A  Smart data link connector – logic.   Steering column control module.   Instrument cluster.  
F23  20A  Audio control module.   CD player module.  
F24  20A  Not used.  
F25  30A  Power window motors (Driver one touch up/down).  

1Trailer wiring provision for authorized Dealer trailer tow module installation.

Battery Fuse Box

Fuse  Fuse amp rating  Protected components  
1  250A  Engine compartment fuse box.  
2  60A  Electronic power steering module.  
3  100A  Body control module.  
4  70A  Supplemental air heater 2 relay  
5  275A  Starter.  

CHANGING A FUSE

Fuses

WARNING   WARNING:  Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.

If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components.

Fuse Types:

Callout  Fuse Type  
A  Micro 2  
B  Micro 3  
C  Maxi  
D  Mini  
E  M Case  
F  J Case  
G  J Case Low Profile  

To download the complete user manual, please download the following file:

https://www.fordservicecontent.com/Ford_Content/vdirsnet/OwnerManual/Home/Index?Variantid=7458&languageCode=EN&countryCode=USA&marketCode=US&bookcode=O146124&VIN=&userMarket=GBR&div=f

Leave a Comment