2022 Hyundai Tucson feature

2022 Hyundai Tucson Scheduled Maintenance Services User Manual

by
Contents hide
1 2022 Hyundai Tucson Scheduled Maintenance Services
2 SCHEDULED MAINTENANCE SERVICES
2.1 Normal maintenance schedule
2.2 Maintenance under severe usage conditions

Hyundai logo

2022 Hyundai Tucson Scheduled Maintenance Services

2022 Hyundai Tucson productSCHEDULED MAINTENANCE SERVICES

Follow Normal Maintenance Schedule if the vehicle is usually operated where none of the following conditions apply. If any of the following conditions apply, you must follow the Maintenance Under Severe Usage Conditions.

  • Repeated driving short distances of fewer than 5 miles (8 km) in normal temperature or less than 10 miles (16 km) in freezing temperature
  • Extensive engine idling or low speed driving for long distances
  • Driving on rough, dusty, muddy, unpaved, graveled, or salt-spread roads
  • Driving in areas using salt or other corrosive materials or in very cold weather
  • Driving in heavy dust conditions
  • Driving in heavy traffic area
  • Driving on the uphill, downhill, or mountain road repeatedly
  • Towing a trailer or using a camper, or driving with loads on the roof
  • Driving as a patrol car, taxi, or other commercial use of vehicle towing
  • Frequently driving under high speed or rapid acceleration/deceleration
  • Frequently driving in stop-and-go condition
  • Engine oil usage which is not recommended (Mineral type, Semi-synthetic, Lower-grade spec, etc.)

If your vehicle is operated under the above conditions, you should inspect, replace or refill more frequently than the following Normal Maintenance Schedule. After the periods of the distance shown in the chart, continue to follow the prescribed maintenance intervals.

Information

  • As it is normal for engine oil to be consumed during driving, the engine oil level should be checked on a regular basis.
  • The engine oil change interval for normal operating conditions is based on the use of the recommended engine specification. If the recommended engine oil specification is not used, then replace the engine oil according to the maintenance schedule under severe operating conditions.

Normal maintenance schedule

MAINTENANCE INTERVALS

MAINTENANCE ITEM

 Number of months or driving distance, whichever comes first
Months 12 24 36 48 60 72 84 96 108 120 132 144 156
Miles×1,000 8 16 24 32 40 48 56 64 72 80 88 96 104
Km×1,000 13 26 39 52 65 78 91 104 117 130 143 156 169
Engine oil and engine oil filter *1 R R R R R R R R R R R R R
Drive belts *2 At first, inspect at 48,000 miles (78,000 km) or 72 months. Thereafter, inspect every 8,000 miles (13,000 km) or 12 months
Fuel additives *3 Add every 8,000 miles (13,000 km) or 12 months
  • Inspect and if necessary, adjust, correct, clean or replace.
  • Replace or change.
  • Check the engine oil level and leak every 350miles (500km) or before starting a long trip. As it is normal for engine oil to be consumed during driving, the engine oil level should be checked on a regular basis. The engine oil change interval for normal operating conditions is based on the use of the recommended engine specification. If the recommended engine oil specification is not used, then replace the engine oil according to the maintenance schedule under severe operating conditions.
    • The drive belt should be replaced when cracks occur or tension is reduced excessively.
    • If TOP TIER Detergent Gasoline is not available, one bottle of additive is recommended. Additives are available from your authorized HYUNDAI dealer along with information on how to use them. Do not mix other additives.

Normal maintenance schedule

MAINTENANCE INTERVALS

MAINTENANCE ITEM

 Number of months or driving distance, whichever comes first
Months 12 24 36 48 60 72 84 96 108 120 132 144 156
Miles×1,000 8 16 24 32 40 48 56 64 72 80 88 96 104
Km×1,000 13 26 39 52 65 78 91 104 117 130 143 156 169
Air cleaner filter I I R I I R I I R I I R I
Spark plugs *4 Replace every 96,000 miles (156,000 km)
Vapor hose, fuel filler cap, and fuel tank I I I I I I
Fuel tank air filter I I I I I I
Fuel lines, hoses, and connections I I I I I I
  • Inspect and if necessary, adjust, correct, clean or replace.
  • Replace or change.
  • For your convenience, it can be replaced prior to its interval when you do maintenance of other items.

Fuel filter: The fuel filter is considered to be maintenance free but periodic inspection is recommended for this maintenance schedule depending on fuel quality. If there are some important matters like fuel flow restriction, surging, loss of power, hard starting problem, etc, replace the fuel filter immediately regardless of the maintenance schedule. We recommend that you consult an authorized HYUNDAI dealer for details.

Normal maintenance schedule

MAINTENANCE Number of months or driving distance, whichever comes first
Months 12 24 36 48 60 72 84 96 108 120 132 144 156
INTERVALS
Miles×1,000 8 16 24 32 40 48 56 64 72 80 88 96 104
MAINTENANCE
ITEM
Km×1,000 13 26 39 52 65 78 91 104 117 130 143 156 169
Engine coolant At first, replace at 120,000 miles (200,000 km) or 120 months. After that, replace every 24,000 miles (40,000 km) or 24 months
Battery condition I I I I I I I I I I I I I
Brake lines, hoses, and connections I I I I I I I I I I I I I
Brake pedal I I I I I I
Parking brake (if equipped) I I I I I I
Brake fluid Inspect every 8,000 miles (13,000 km) or 12 months,

Replace every 48,000 miles (78,000 km) or 48 months
  1. Inspect and if necessary, adjust, correct, clean or replace.
  2. Replace or change.

Normal maintenance schedule

MAINTENANCE INTERVALS

MAINTENANCE ITEM

 Number of months or driving distance, whichever comes first
Months 12 24 36 48 60 72 84 96 108 120 132 144 156
Miles×1,000 8 16 24 32 40 48 56 64 72 80 88 96 104
Km×1,000 13 26 39 52 65 78 91 104 117 130 143 156 169
Disc brakes and pads I I I I I I I I I I I I I
Steering gear rack, linkage, and boots I I I
Tire (pressure & treadwear) I I I I I I I I I I I I I
Suspension mounting bolts I I I I I I I I I I I I I
Air conditioner refrigerant I I I I I I I I I I I I I
Air conditioner compressor I I I I I I I I I I I I I
Cabin air filter Replace every 16,000 miles (25,000 km) or 12 months
Automatic transmission fluid No check, No service required
Exhaust pipe and muffler I I I I I I I I I I I I I
Rear differential oil *6 I I I
Transfer case oil (AWD) No check, No service required
Driveshaft I I I I I I I I I I I I I
  • Inspect and if necessary, adjust, correct, clean or replace.
  • Replace or change.
  • Rear differential oil should be changed anytime, the front/rear differential has been submerged in water.

Maintenance under severe usage conditions

The following items must be serviced more frequently on cars mainly used under severe driving conditions. Refer to the chart below for the appropriate maintenance intervals.

  • Replace
  • Inspect and if necessary, adjust, correct, clean, or replace
    Maintenance item Maintenance operation Maintenance intervals Driving condition
    Engine oil and engine oil filter*1

    R

    		 Replace every 5,000 miles (8,000 km) or 6 months A, B, C, D, E,

    F, G, H, I, J, K, L

    Air cleaner filter

    R

    		 Replace more frequently depending on the condition

    C, E

    Spark plugs

    R

    		 Replace more frequently depending on the condition A, B, F, G, H, I, K
    Steering gearbox, linkage & boots / lower arm ball joint, upper arm ball joint

    I

    		 Inspect more frequently depending on the condition C, D, E, F, G, H, I
    Disc brakes and pads, calipers and rotors

    I

    		 Inspect more frequently depending on the condition C, D, G, H, J, K
    • Requires <API Latest (or ILSAC Latest) Full synthetic> grade engine oil. If a lower grade engine oil (mineral oil including Semi-synthetic) is used, then the engine oil and engine oil filter must be replaced as indicated severe maintenance condition.
      Maintenance item Maintenance operation Maintenance intervals Driving condition

      Parking brake (if equipped)

      I

      		 Inspect more frequently depending on the condition

      C, D, G, H
      Climate control air filter

      (for evaporator and blower unit)

      R

      		 Replace more frequently depending on the condition

      C, E
      Automatic transmission fluid R Replace every 60,000

      miles (96,000 km)

      		 A, C, E, F, G, H, I, K
      Rear differential oil R Replace every 72,000

      miles (120,000 km)

      		 C, D, E, G, H, I, J
      Transfer case oil (AWD) – No check, No service required –

      Drive shaft

      I

      		 Inspect more frequently depending on the condition C, D, E, F,

      G, H, I, J

Severe driving conditions

  • A. Repeatedly driving short distances of less than 5 miles (8 km) in normal temperature or less than 10 miles (16 km) in freezing temperature
  • B. Extensive engine idling or low speed driving for long distances
  • C. Driving on rough, dusty, muddy, unpaved, graveled, or salt spread roads
  • D. Driving in areas using salt or other corrosive materials or in very cold weather
  • E. Driving in the condition of inflowing sand or dust into the engine
  • F. Driving in heavy traffic area
  • G. Driving on the uphill, downhill, or mountain roads
  • H. Towing a trailer or using a camper, or driving with loads on the roof
  • I. Driving for a patrol car, taxi, commercial car, or vehicle towing
  • J. Frequently driving under high speed or rapid acceleration/deceleration
  • K. Frequently driving in stop-and-go conditions
  • L. Engine oil usage which is not recommended (Mineral type, Semi-synthetic, Lower-grade spec, etc.)

Leave a Comment