2019 Ford F-550 Fuse Box Diagram

Power Distribution Box

WARNING:  Always disconnect the battery before servicing high current fuses.    WARNING:  To reduce risk of electrical shock, always replace the cover to the power distribution box before reconnecting the battery or refilling fluid reservoirs.

The power distribution box is in the engine compartment. It has high-current fuses that protect your vehicle’s main electrical systems from overloads.If the battery has been disconnected and reconnected, some features need to be reset. 

Fuse or Relay Number	Fuse Rating	Protected Component
1	20A1	Powertrain control module.
2	20A1	Emissions – malfunction indicator lamp.
3	20A1	Cooling fan.   A/C compressor.   Engine brake.
4	20A1	Noise suppression cap.   Mass air flow sensor.   Emissions.   Glow plugs.   Urea.
5	15A1	Compressed natural gas fuel control module.   Fuel sensor.
6	—	Not used.
7	—	Not used.
8	—	Not used.
9	—	Not used.
10	15A1	Heated exterior mirrors.
11	—	Compressed natural gas relay.
12	40A2	Heated rear window.
13	—	Not used.
14	—	Powertrain control module relay.
15	20A1	Horn.
16	10A1	A/C clutch relay power.
17	—	Rear heated window and heated mirrors relay.
18	—	Trailer park lamp relay.
19	—	Not used.
20	—	Supplemental air heater bank #1 relay.
21	—	Not used.
22	—	Not used.
23	—	Not used.
24	—	Cooling fan relay.   Supplemental air heater bank #3 relay.
25	—	Glow plug module power relay.
26	—	Not used.
27	30A2	Trailer tow battery charge relay (if equipped).
28	—	Not used.
29	—	Run-start relay.
30	10A1	4×4 module.
31	5A1	Adaptive cruise control.   Run-start.
32	5A1	Anti-lock brake system module.   Run-start.
33	10A1	Powertrain control module – ignition status power run.   Run-start.   Engine control module.   Transmission control module.
34	10A1	Blind spot information system.   Run-start.   Front camera.   Rear camera.
35	—	Not used.
36	—	Blower motor relay.
37	—	Trailer tow battery charge relay (only on non-trailer brake controller vehicles).
38	—	A/C compressor clutch relay.
39	—	Horn relay.
40	—	Supplemental air heater bank #2 relay.
41	25A2	Glow plugs.
42	40A2	Trailer tow lighting module (if equipped).
43	40A2	Front blower motor.
44	50A3	Voltage quality.   Body control module power.
45	60A3	Active front steering.
46	50A3	Supplemental air heater bank #2.
47	50A3	Cooling fan.   Supplemental air heater bank #3.
48	50A3	Body control module run power 1 bus.
49	60A3	Inverter.
50	50A3	Body control module run power 2 bus.
51	60A3	Body control module B+ feed.
52	60A3	Anti-lock brake system pump.
53	50A3	Supplemental air heater bank #1.
54	30A3	Trailer brake control module.
55	30A3	Climate controlled seat module.
56	40A3	Auxiliary lighting module.
57	30A2	Power running boards.
58	30A2	Compressed natural gas fuel control module relay.
59	30A2	Anti-lock brake system valve.
60	—	Not used.
61	30A2	Driver power seat.
62	20A2	Auxiliary power point #1 (instrument panel).
63	30A2	Starter motor.
64	20A2	Auxiliary power point #2.
65	30A2	Trailer tow lighting module (if equipped).
66	20A2	Auxiliary power point #3 (center console).
67	30A2	Passenger power seat.
68	20A2	Auxiliary power point #4 (USB charger, rear center console).
69	25A2	4×4 module.
70	20A2	Auxiliary power point #5 (rear center console).
71	—	Not used.
72	30A2	Trailer tow left hand/right hand stop/turn (if equipped, not present with trailer brake controller).
73	—	Not used.
74	—	Not used.
75	30A2	Fuel pump.
76	—	Not used.
77	30A2	Wiper motor.
78	—	Not used.
79	30A2	Power sliding rear window.
80	25A1	4×4 module.
81	10A1	4×4 solenoid.
82	10A1	Power telescoping mirrors.
83	20A1	Rear heated seats.
84	10A1	Trailer tow backup lamps (if equipped).
85	—	Not used.
86	—	Not used.
87	—	Not used.
88	10A1	Multi contour seats.
89	—	Not used.
90	10A1	Spot light module.
91	10A1	Upfitter interface module.
92	—	Not used.
93	—	Not used.
94	15A1	Transmission control module.
95	10A1	Powertrain control module keep alive power.
96	5A1	Rain sensor.
97	10A1	Run/Start control for Auxiliary power point #5
98	10A 1	Alternator sense.
99	30A 1	Trailer tow parking lamps.

¹Micro fuse.²M case fuse.³J case fuse.

Passenger Compartment Fuse Panel

The fuse panel is in the right-hand side of the passenger footwell behind a trim panel. To remove the trim panel, pull it toward you and swing it away from the side. To reinstall it, line up the tabs with the grooves on the panel, and then push it shut.

Note:   It may be easier to access the fuse panel if you remove the finish trim piece.

Fuse or Relay Number	Fuse Rating	Protected Component
1	—	Not used.
2	7.5A4	Memory seat switch (lumbar power).
3	20A4	Driver door unlock relay.
4	5A4	Aftermarket electronic brake controller.   Trailer brake controller Brake On/Off.   Customer access circuits.
5	—	Not used.
6	—	Not used.
7	—	Not used.
8	10A5	Driver window switch mirror fold.
9	10A5	Brake On/Off / Pressure Switch.
10	5A4	Embedded Modem.
11	5A5	Combined sense security module.
12	7.5A5	Front climate control module.
13	7.5A5	Instrument cluster.   Smart data link.   Steering column control module.
14	10A5	Extended power restraints module.
15	10A5	Smart datalink connector power.
16	15A4	Tailgate release solenoid.
17	5A5	Head-up display.
18	5A5	Push button ignition switch.   Ignition switch.   Key inhibit.
19	7.5A5	Transmission control switch (tow/haul).   Select Shift switch.
20	7.5A5	Active front steering module.
21	5A5	Head-up display.   Humidity sensor.
22	5A5	Upfitter switch.   Run/Start.   PTO relays.
23	10A4	Accessory delay.   Power windows.   Moonroof.   Power folding mirrors relay.   Inverter.   Window/moonroof switch illumination.
24	20A4	Central locking system relay.
25	30A4	Left-hand front smart window motor.   Door zone module.
26	30A4	Right-hand front smart window motor.   Door zone module.
27	30A4	Moonroof.
28	—	Not used.
29	30A4	Bang & Olufsen Amplifier.
30	—	Not used.
31	15A4	Adjustable pedals switch.
32	10A4	SYNC.   GPS module.   Display.   Radio frequency receiver.
33	20A4	Radio.
34	30A4	Run-start relay.
35	5A4	Extended power restraints module.
36	15A4	Lane keeping system.   Automatic high beam control.   Auto-dimming mirrors.   Rear heated seats.   Camera module.
37	20A4	Heated steering wheel.
38	30A6	Rear power window switch.

⁴Micro 2 fuse.⁵Micro 3 fuse.⁶Circuit breaker.

2019 Ford F-550 Owners Manual

Changing a Fuse

Fuses

WARNING:  Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.

If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components.Fuse Types

Callout	Fuse Type
A	Micro 2
B	Micro 3
C	Maxi
D	Mini
E	M Case
F	J Case
G	J Case Low Profile