2023 Volvo S90/ S90 Recharge Plug In Hybrid Fuses
Fuses and central electrical units
Electrical functions and components are protected by a number of fuses in order to protect the car’s electrical system from damage by short circuiting or overloading. The fuses are fitted in the car’s various fuse boxes.
Warning
- Never replace a fuse with a foreign object or a fuse of higher amperage. This may lead to damage to the electrical system and cause fire.
- Contact an authorised Volvo workshop about replacing the fuses not described in the owner’s manual.
- Orange-coloured cables must only be handled by qualified personnel.
- Several components in the car work with high-voltage current that could be dangerous in the event of incorrect intervention.
- Do not touch anything that is not clearly described in the owner’s manual for the car.
- If an electrical component or function does not work, it may be because the component’s fuse was overloaded, which must be changed. If the same fuse is overloaded repeatedly then there is a fault in the component. Volvo recommends contacting an authorised Volvo workshop for checking.
Location of central electrical units
The figure is schematic – appearance may vary depending on car model.
Central electrical unit locations in a left-hand drive car – for a right-hand drive car, the central electrical units under the glovebox change sides.
| 1 | Engine compartment |
| 2 | Under the glovebox |
| 3 | Cargo area |
Replacing a fuse
- A fuse that has been overloaded needs to be changed in order to restore the function of the electrical component it is protecting.
- Locate the correct fuse in the fuse lists for the various fuse boxes.
- Pull out the fuse and check from the side to see whether the curved wire has blown.
- If this is the case, replace it with a new fuse of the same colour and amperage.
Note
Some fuse boxes may contain special tweezers for a better grip on the fuse.
Warning
- Never replace a fuse with a foreign object or a fuse of higher amperage. This may lead to damage to the electrical system and cause fire.
- Contact an authorised Volvo workshop about replacing the fuses not described in the owner’s manual.
- Contact an authorised Volvo workshop about replacing the fuses not described in the owner’s manual.
Fuses under glovebox
The fuses in the fuse box under the glovebox protect components such as electrical sockets, displays and door modules.
The fuse box is located behind the floor mat/side panel.- The fuse box in the engine compartment provides space for several spare fuses.
Positions
- The positions of the fuses are shown on the inside of the cover. Functions and components in the fuse table cover several models and engine alternatives. A fuse description can therefore apply to fewer than those in the table, or be completely missing, depending on how the car is equipped.
- If a position has multiple table values, it is due to variations in equipment level. In which case, follow the value of the fuse being replaced. In the event of doubt – contact a workshop. An authorised Volvo workshop is recommended.
| 1 | Function | Ampere | Type |
|---|---|---|---|
| 1 | Control module, 48 V battery | 10 | Micro |
| 2 | – | – | MCase |
| 3 | – | – | Micro |
| 4 | Movement detector | 5 | Micro |
| 5 | – | – | Micro |
| 6 | Driver display | 5 | Micro |
| 7 | Keypad, centre console | 5 | Micro |
| 8 | Sun sensor
Toll collection transponder |
5 | Micro |
| 9 | – | – | Micro |
| 10 | Infotainment system | 15 | Micro |
| 11 | Steering wheel module | 5 | Micro |
| 12 | Control module, start knob and parking brake | 5 | Micro |
| 13 | Heated steering wheel | 15 | Micro |
| 14 | Airborne Particulate Matter Sensor (APMS) | 5 | Micro |
| 15 | – | – | Micro |
| 16 | – | – | Micro |
| 17 | Control module, rear lighting | 15 | Micro |
| 18 | Control module, climate control | 10 | Micro |
| 19 | Steering lock | 7,5 | Micro |
| 20 | Diagnostic port OBD-II | 10 | Micro |
| 21 | Centre display | 5 | Micro |
| 22 | Fan module, climate control, front | 40 | MCase |
| 23 | USB hub | 5 | Micro |
| 24 | Controls lighting
Passenger compartment lighting Dimming, interior rearview mirror Rain and light sensors Power front seats Control panels, rear doors Fan module, climate control Ioniser Keypad, tunnel console at legroom rear seat |
7,5 | Micro |
| 25 | Camera, front | 5 | Micro |
| 256 | Roof console | 20 | Micro |
| 127 | Head-up display | 5 | Micro |
| 28 | Passenger compartment lighting | 5 | Micro |
| 29 | Wireless charging plate | 5 | Micro |
| 30 | Display roof console | 5 | Micro |
| 31 | – | – | Micro |
| 32 | – | – | Micro |
| 33 | – | – | Micro |
| 34 | Electric motor, rear | 10 | Micro |
| 35 | Control module, online car
Control module, Volvo Services |
5 | Micro |
| 36 | – | – | Micro |
| 37 | Audio control device (amplifier) | 40 | MCase |
| 38 | – | – | MCase |
| 39 | Antenna module (TCAM) | 5 | Micro |
| 40 | Control module, seat comfort, front | 5 | Micro |
| 41 | Alcohol lock
– |
5
– |
Micro |
| 42 | – | – | Micro |
| 43 | Control module, fuel pump | 15 | Micro |
| 44 | Relay coil, transmission oil pump | 5 | Micro |
| 45 | Control module, driver support functions (active safety) | 5 | Micro |
| 46 | Seat heating, driver’s side front | 15 | Micro |
| 47 | Seat heating, passenger side front | 15 | Micro |
| 48 | Coolant pump | 7,5 | Micro |
| 49 | Air cleaner | 5 | Micro |
| 50 | Power driver’s seat | 20 | Micro |
| 51 | Module, active damping | 20 | Micro |
| 52 | Opening the boot lid/tailgate with foot motion | 5 | Micro |
| 53 | Infotainment system | 10 | Micro |
| 54 | – | – | MCase |
| 55 | – | – | Micro |
| 56 | Electrically operated front passenger seat | 20 | Micro |
| 57 | – | – | Micro |
| 58 | – | – | Micro |
| 59 | Primary fuse infotainment | 15 | Micro |
Fuses in cargo area
The fuse box with the cargo area fuses is located behind a panel on the right side.
The central electrical unit is located behind the panel on the right-hand side.- Special pliers are housed on the inside of the cover to facilitate replacement of tripped fuses.
- The fuse box in the engine compartment provides space for several spare fuses.
Positions
The positions of the fuses are shown on the inside of the cover. Functions and components in the fuse table cover several models and engine alternatives. A fuse description can therefore apply to fewer than those in the table, or be completely missing, depending on how the car is equipped.If a position has multiple table values, it is due to variations in equipment level. In which case, follow the value of the fuse being replaced. In the event of doubt – contact a workshop. An authorised Volvo workshop is recommended.
| Function | Ampere | Type | |
|---|---|---|---|
| 1 | Rear window defroster | 30 | MCase |
| 2 | Central electronic module | 40 | MCase |
| 3 | Compressor, air suspension | 40 | MCase |
| 4 | Lock motor backrest, right rear | 15 | MCase |
| 5 | – | – | MCase |
| 6 | Lock motor backrest, left rear | 15 | MCase |
| 7 | Door module, right rear | 20 | MCase |
| 8 | Control module for reduction of nitrous oxides (diesel) | 30 | MCase |
| 9 | Power operated boot lid | 25 | MCase |
| 10 | Door module, right front | 20 | MCase |
| 11 | Towbar control module | 40 | MCase |
| 12 | Seatbelt pretensioner, right | 40 | MCase |
| 13 | Internal relay coils | 5 | Micro |
| 14 | Control module for reduction of nitrous oxides (diesel) | 15 | Micro |
| 15 | Door module, left rear | 20 | Micro |
| 16 | Alcohol lock | 5 | Micro |
| 17 | – | – | Micro |
| 18 | Towbar control module | 25 | MCase |
| Accessory module | 40 | ||
| 19 | Door module, left front | 20 | MCase |
| 20 | Seatbelt pretensioner, left | 40 | MCase |
| 21 | Parking camera | 5 | Micro |
| 22 | Rear lighting (backup) | 10 | Micro |
| 23 | – | – | Micro |
| 24 | Position prepared for special vehicle | 5 | Micro |
| 25 | Supply when the ignition is switched on | 10 | Micro |
| 26 | – | – | Micro |
| 27 | – | – | Micro |
| 28 | Seat heating, left rear | 15 | Micro |
| 29 | – | – | Micro |
| 30 | Blind Spot Information (BLIS) | 5 | Micro |
| 31 | – | – | Micro |
| 32 | Seatbelt pretensioner, left | 5 | Micro |
| 33 | Actuator, exhaust system (petrol) | 5 | Micro |
| 34 | – | – | Micro |
| 35 | Control module All Wheel Drive (AWD) | 15 | Micro |
| 36 | Seat heating, right rear | 15 | Micro |
| 37 | – | – | MCase |
Fuses in engine compartment
Among other things, the engine compartment fuses protect functions related to the engine and the brake system.
- Special pliers are housed on the inside of the cover to facilitate replacement of tripped fuses.
- The fuse box also provides space for several spare fuses.
Positions
Fuse locations are shown on the inside of the cover. Functions and components in the fuse table cover several models and engine alternatives. A fuse description can therefore apply to fewer than those in the table, or be completely missing, depending on how the car is equipped.
If a position has multiple table values, it is due to variations in equipment level. In which case, follow the value of the fuse being replaced. In the event of doubt – contact a workshop. An authorised Volvo workshop is recommended.
| Function | Ampere | Type | |
|---|---|---|---|
| 1 | – | – | Micro |
| 2 | – | – | Micro |
| 3 | – | – | Micro |
| 4 | Control module, transmission actuator | 5 | Micro |
| 5 | Control module, coolant heating | 5 | Micro |
| 6 | Air conditioning | 5 | Micro |
| 7 | Control module, hybrid battery
High voltage converter, high-voltage generator/starter motor |
5 | Micro |
| 8 | – | – | Micro |
| 9 | – | – | Micro |
| 10 | Control module, hybrid battery
High voltage converter, high-voltage generator/starter motor |
10 | Micro |
| 11 | Charging unit | 5 | Micro |
| 12 | Shut-off valve, hybrid battery cooling
Coolant pump, hybrid battery |
15 | Micro |
| 13 | Coolant pump, electric drive system | 15 | Micro |
| 14 | Cooing fan, hybrid components | 25 | MCase |
| 15 | – | – | MCase |
| 16 | – | – | MCase |
| 17 | – | – | MCase |
| 18 | Calculation unit | 5 | Micro |
| 19 | – | – | Micro |
| 20 | – | – | Micro |
| 21 | – | – | Micro |
| 22 | – | – | Micro |
| 23 | USB port, tunnel console, rear | 7,5 | Micro |
| 24 | 12 V socket, tunnel console, front | 15 | Micro |
| 25 | – | – | Micro |
| 26 | 12 V socket cargo area | 15 | Micro |
| 27 | Spare fuse | 5 | Micro |
| 28 | Headlamp, left | 15 | Micro |
| 29 | Headlamp, right | 15 | Micro |
| 30 | Spare fuse | 10 | Micro |
| 31 | Heated windscreen, left | Shunt | MCase |
| 32 | Heated windscreen, left | 40 | MCase |
| 33 | Headlamp washers | 25 | MCase |
| 34 | Windscreen washers | 25 | MCase |
| 35 | – | – | Micro |
| 36 | Horn (honk) | 20 | Micro |
| 37 | Siren | 5 | Micro |
| 38 | Control module, brake system (valves, parking brake) | 30 | MCase |
| 39 | Windscreen wipers | 30 | MCase |
| 40 | – | – | MCase |
| 41 | Heated windscreen right-hand side | 40 | MCase |
| 42 | Parking heater | 20 | MCase |
| 43 | – | – | MCase |
| 44 | – | – | MCase |
| 45 | Heated windscreen, right | Shunt | MCase |
| 46 | Supplied when the ignition is switched on: Engine control module, Transmission components, Electric steering servo, Central electronic module | 5 | Micro |
| 47 | Exterior car noise (certain markets) | 5 | Micro |
| 48 | Headlamp, right | 15 | Micro |
| 49 | Alcohol lock
– |
5
– |
Micro |
| 50 | – | – | Micro |
| 51 | Radar, front | 5 | Micro |
| 52 | Collision module (SRS)
|
5 | Micro |
| 53 | Headlamp, left | 15 | Micro |
| 54 | Accelerator pedal sensor | 5 | Micro |
| 55 | Transmission control module
Control module, gear selector |
15 | Micro |
| 56 | Engine Control Module (ECM) | 5 | Micro |
| 57 | – | – | Micro |
| 58 | – | – | Micro |
| 59 | – | – | Micro |
| 60 | – | – | Micro |
| 61 | Engine Control Module (ECM)
Throttle control module Actuator, switch, compressor |
20 | Micro |
| 62 | Engine component group 1 (components related to engine function, including turbo/compressor. Contents depend on engine alternative.) | 10 | Micro |
| 63 | Engine component group 2 (components related to engine function, including turbo. Contents depend on engine alternative.)
Switching valve, air conditioning |
7,5 | Micro |
| 64 | Control module, spoiler damper
Control module, radiator damper |
5 | Micro |
| 65 | – | – | Micro |
| 66 | Lambda probe | 15 | Micro |
| 67 | Solenoid engine oil pump
Lambda probes Solenoid air conditioning compressor |
15 | Micro |
| 68 | – | – | Micro |
| 69 | Engine Control Module (ECM) | 20 | Micro |
| 70 | Spark plugs/ignition coils | 15 | Micro |
| 71 | – | – | MCase |
| 72 | – | – | MCase |
| 73 | Control module, transmission oil pump | 30 | MCase |
| 74 | – | – | MCase |
| 75 | Actuator, transmission | 25 | MCase |
| 76 | – | – | MCase |
| 77 | – | – | MCase |
| 78 | – | – | MCase |